|
15 |
|
 |
*00-III
To search this page please hit
CTRL+F on your Keyboard
GROUP 15 INDEX
-----------------------
DIAGRAM 1 TO 3 0000 O3
SPARK PLUGS, REPLACE 1010 940914
IGNITION SYSTEM, TEST (ENG. WITH CFI (CIS/CIS-E) 1250 930405
SPARK PLUG CABLES, ALL - ENGINES WITH CFI 1310 971031
SPARK PLUG CABLES, ALL - ENGINES WITH SFI 1311 971031
SPARK PLUG CABLE, ONE - ENGINES WITH CFI 1320 971031
SPARK PLUG CABLE, ONE - ENGINES WITH SFI 1321 971031
IGNITION CABLE - CONTROL MODULE TO DISTRIBUTOR 1360 971031
INGNTION/SPARK PLUG CABLE(S) - ASSEMBLE 1471 971031
SPARK PLUG CONNECTOR(S) 1610 971031
IGNITION SYSTEM TESTS - ENGINES WITH SFI 1905 971205
IGNITION COIL(S) 2013 971031
DIAGNOSTIC SOCKET (X11), REPL. 2073 920626
IGNITION CONTROL MODULE 2093 920626
CRANKSHAFT POSITION SENSOR 2133 900517
CAMSHAFT POSITION SENSOR 2143 910114
CAMSHAFT HALL EFFECT SENSOR, REPL. 2148 950804
REFERENCE RESISTOR 2153 950804
VACUUM LINES - IGNITION SYSTEM 2173 910110
KNOCK SENSOR(S) - IGNITION SYSTEM 2183 971031
ENGINE SYSTEMS (MAS) CONTROL MODULE 2193 920626
HIGH VOLTAGE DISTRIBUTOR, CHECK / ADJ. / R & R 2810 920626
HIGH VOLTAGE DISTRIBUTOR PARTS, REPL. 3213 920626
TRANSM. OVERLOAD PROTECTION SWITCH, TEST / REPL. 3611 930126
DIESEL PREGLOW SYSTEM TESTS & REPLACEMENTS 4000 970227
GENERATOR, TEST / R & R / REPL. 5010 940923
GENERATOR PARTS, REPL. 5710 971031
WIRING HARNESS TO GENERATOR, REPL. 6052 940923
GENERATOR CARRIER & SUPPORT 6212 970227
STARTER MOTOR 7020 940407
STARTER CABLE RUBBER BOOT 7780
INCLUDED OPERATIONS AS REQUIRED
15- B EFF DATE: 11-01-03
+ 15-D01
+ 15-D02
+ 15-D03
+ 15-TTT
-
SPARK PLUGS, REPLACE
-----------
15-1010 * SPARK PLUGS, R & R / REPL. IF REQ. .2 21
.3 A1/22/23/26/27/41
44/45/47/74/75/82
83/84/85/88/91
.5 10
A2/A3/A7/A8/51/52
53/54/55/67/68/71
72/73
.6 B1/B2/C2/C3/62/63
64/65/89/95
.7 C1/C4/C7/G1/G2/94
.8 A4/A9/Q3/92/93
1.0 E2/P5/Q1
1.4 B3/B7/B8/E3/96
1.8 B4/B9/97
1.9 S1/S4/U1/U4
2.0 S2/S3/S5/S6
2.1 C6/J1/M1/M2/M3/M5
M6/M7/M9/N1/N3/N5
R2/T2/T3/T5/98
2.2 C5/E6/E7/E8/E9/F1
G3/G4/H1/H3/P1/P2
P3/P4/P6/P7/P8/P9
Q2/Q4/T1/T4/U2/U3
2.3 H2/H4/H5/H6
2.4 R1
2.5 E4/F2
3.8 M8
4.0 M4/N2/N4
15-004 EFF DATE: 11-01-03
+ 15-TTT
-
IGNITION SYSTEM, TEST (ENG. WITH CFI (CIS/CIS-E)
---------------
15-1250 * IGNITION SYSTEM - ENG. WITH CFI, TEST .3 26/27/41/44/45/47
82/83/84/85/88
.4 11/12/15/51/52/53
54/55/71/72/73/74
75/91/92
SPARK PLUG CABLES, ALL - ENGINES WITH CFI
-----------------
15-1310 SPARK PLUG CABLES, ALL - ENGINE WITH CFI, REPL. .4 20
.5 74/75
.6 26/27/41/45/47/82
83/84/85/88/91
.7 44
1.2 10
51/52/53/54/55/71
72/73
15-005 EFF DATE: 11-01-03
+ 15-TTT
-
SPARK PLUG CABLES, ALL - ENGINES WITH SFI
-----------------
15-1311 SPARK PLUG CABLES, ALL - ENGINE WITH SFI, REPL. .0 C6/M4/M8/R2
(AFTER TEST) .2 G0/N0
A1/B1/B2/C1/C2/C3
C4/C5/C7/E2/E3/E4
E6/E7/E8/E9/F1/F2
H1/H2/H3/H4/H5/J1
M1/M2/M3/M5/M6/M7
M9/P5/62/63/64/65
89/95/98
.5 A2/A3/A7/A8/67/68
93/96
.7 S2/S3/S5/S6
.8 P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4
.9 S1/S4
1.0 T1/T4/U1/U4
1.4 T2/T3/T5/U2/U3
1.6 R1
15-1312 SPARK PLUG CABLES, ALL - ENGINE WITH SFI, REPL. .1 G0
(INTAKE MANIFOLD REMOVED) .7 A4/A9/94
15-006 EFF DATE: 11-01-03
+ 15-TTT
-
SPARK PLUG CABLE, ONE - ENGINES WITH CFI
----------------
15-1320 SPARK PLUG CABLE, ONE - ENGINE WITH CFI, REPL. .2 10/20
51/52/53/54/55/71
72/73
.3 26/27/41/45/47/74
75/82/83/84/85/88
91/92
.4 44
SPARK PLUG CABLE, ONE - ENGINES WITH SFI
----------------
15-1321 SPARK PLUG CABLE, ONE - ENGINE WITH SFI, REPL. .0 C6/R2
(AFTER SPARK PLUG CABLES/CONNECTORS TEST) .1 G0/H0/M0/N0
A1/B1/B2/C1/C2/C3
C4/C5/C7/E2/E3/E4
E6/E7/E8/E9/F1/F2
J1/P0/Q0/S1/S2/S4
S5/S6/62/63/64/65
89/95/98
.3 A2/A3/A7/A8/S3/T1
T2/T3/T4/T5/U1/U2
U3/U4/67/68/93
.6 R1
15-1322 SPARK PLUG CABLE, ONE - ENGINE WITH SFI, REPL. .3 A4/A9/94/97
(INTAKE MANIFOLD REMOVED)
15-007 EFF DATE: 11-01-03
+ 15-TTT
-
IGNITION CABLE - CONTROL MODULE TO DISTRIBUTOR
--------------
15-1360 IGNITION CABLE - IGN. CONTROL MODULE TO DISTRIBUTOR, REPL. .2 47
.3 11/12/15/51/52/53
54/55/71/72/73/91
92
IGNITION/SPARK PLUG CABLE(S) - ASSEMBLE
-----------------------------
15-1471 IGNITION/SPARK PLUG CABLES - ALL, ASSEMBLE FROM NEW PARTS .0 C5/C6
.2 G1/G2
.3 20/25
A1/B1/B2/C1/C2/C3
C4/C7/E2/E6/E7/E8
E9/G3/G4/H1/H3/41
44/45/47/62/63/64
65/74/75/82/83/84
85/88/89/91/95
.4 10
A2/A3/A7/A8/E3/E4
F1/F2/H2/H4/H5/H6
51/52/53/54/55/67
68/71/72/73/92/93
96
.6 A4/A9/94/97
15-1476 IGNITION/SPARK PLUG CABLE - ONE, ASSEMBLE FROM NEW PARTS .1 B0/C0/G0/H0/M0/N0
10/25/90
A1/A2/A3/A4/A7/A8
A9/E2/E3/E4/E6/E7
E8/E9/F1/F2/J1/41
44/45/47/51/52/53
54/55/62/63/64/65
67/68/71/72/73/74
75/82/83/84/85/88
15-008 EFF DATE: 11-01-03
+ 15-TTT
-
SPARK PLUG CONNECTOR(S)
-----------------------
15-1610 SPARK PLUG CONNECTORS - ALL, REPL. .3 20/25
41/45/47/74/75/82
83/84/85/88
.4 10
44/51/52/53/54/55
71/72/73/91/92
15-1620 SPARK PLUG CONNECTOR - ONE, REPL. .2 10/20/25
51/52/53/54/55/71
72/73/74/75/82/83
84/85/88/91/92
.3 41/44/45/47
15-009 EFF DATE: 11-01-03
+ 15-TTT
-
IGNITION SYSTEM TESTS - ENGINES WITH SFI
---------------------
15-1905 * ELECTRICAL TEST PROGRAM - IGNITION SYST., SOCKET BOX CONNECT .1 B0/C0/90
(AFTER DIAGNOSIS) A1/A2/A3/A4/A7/A8
A9/P0/Q0/62/63/64
65/67/68/89
15-1906 * IGNITION COMPONENTS, TEST ACCORDING TO DTC READOUT, PERFORM .0 C5/P0/Q0/89/98
.6 C1/C4
.7 A1/B1/B2/C2/C3/62
63/64/65/95
.8 A2/A3/A7/A8/67/68
93/94/96/97
.9 A4/A9
15-1908 KNOCK SENSOR (1) TEST - W/DAS (AFTER ENG. TEST),PERFORM .0 H5/H6
.1 M0/N0
E2/E3/E4/E6/E7/E8
E9/F2/G1/G2/G3/H1
H2/H3/H4/J1/P0/Q0
U0
15-1909 KNOCK SENSOR (ALL) TEST - W/DAS (AFTER ENG. TEST),PERFORM .2 M0
E2/E3/E4/E6/E7/E8
E9/F2/G3/H1/H2/H3
H4/J1/P0/Q0/S1/S2
S3/S4/S5/S6/U0
15-1910 VOLTAGE SUPPLY TO IGNITION CONTROL MODULE, TEST .2 A1/A2/A3/A4/A7/A8
A9/67/68/93/94
15-1912 * REFERENCE RESISTOR (KNOCK SENSOR IC) - IGN. SYST., TEST .1 A1/A2/A3/A4/A7/A8
A9/67/68/93/94
15-010 EFF DATE: 11-01-03
+ 15-TTT
-
15-1914 * TN (ENGINE RPM) SIGNAL - FOR IGNITION SYSTEM, TEST .1 90
A1/A2/A3/A4/A7/A8
A9/B1/B2/B3/B4/B7
B8/B9/62/63/64/65
67/68/89
.2 P0
15-1916 * CAN BUS - IGNITION SYSTEM, TEST .2 A1/A2/A3/A4/A7/A8
A9/B1/B2/B3/B4/B7
B8/B9/67/68/93/94
95/96/97/98
.3 62/63/64/65/89
15-1917 CAMSHAFT HALL SENSOR - IGNITION SYSTEM, TEST .0 C6
.2 E2/E3/E4/E6/E7/E8
E9/F1/F2
.3 B3/B4/B7/B8/B9/C5
96/97/98
15-1918 * CAMSHAFT POSITION SENSOR - IGNITION SYSTEM, TEST .3 A1/A2/A3/A4/A7/A8
A9/B1/B2/62/63/64
65/67/68/89/95
15-1920 * CRANKSHAFT POSITION SENSOR - IGNITION SYSTEM, TEST .2 E0
F1/F2
.3 90
A1/A2/A3/A4/A7/A8
A9/B1/B2/B3/B4/B7
B8/B9/62/63/64/65
67/68/89
15-011 EFF DATE: 11-01-03
+ 15-TTT
-
15-1922 * IGNITION COIL(S) - ENG. WITH SFI-TEST, PERFORM .0 C6
.2 A1/A4/A9/B1/B2/G1
G2/62/63/64/65/89
91/94/97
.3 A2/A3/A7/A8/C1/C2
C3/C4/C5/C7/G3/G4
67/68/92/93/95/96
98
.5 B3/B7/B8
.7 B4/B9
15-1924 * SPARK PLUG CABLES/CONNECTORS - ENGINE WITH SFI, TEST .0 C6/M4/M8/N2/N4/R1
.0 R2/U0
.5 G1/G2
.6 C1/C4/C7/P5/Q1/Q3
.7 A1/B1/B2
.8 C2/C3/C5/E2/E4/E6
E7/E8/E9/F1/F2/G3
G4/H1/H2/H3/H4/H5
H6/J1/M1/M2/M3/M5
M6/M7/M9/N1/N3/N5
P1/P2/P3/P4/Q2/Q4
S1/S2/S3/S4/S5/S6
T1/T2/T3/T4/T5/62
63/64/65/89/95/98
15-1925 * SPARK PLUG CABLES/CONNECTORS - L/SIDE OF ENG. WITH SFI, TEST .3 E3
.6 A2/A3/A4/A7/A8/A9
67/68/93/94/96/97
15-1926 * SPARK PLUG CABLES/CONNECTORS - R/SIDE OF ENG. WITH SFI, TEST .3 E3
.6 A2/A3/A4/A7/A8/A9
67/68/93/94/96/97
15-1928 * H.V. DISTR. CAP/ROTOR, SINGLE - ENG. WITH SFI, TEST / REPL. .4 A1
15-012 EFF DATE: 11-01-03
+ 15-TTT
-
15-1929 * H.V. DISTR. CAP/ROTOR, L/SIDE - ENG. WITH SFI, TEST / REPL. .4 A2/A3/A4/A7/A8/67
68/92/93/94
.5 A9
15-1930 * H.V. DISTR. CAP/ROTOR, R/SIDE - ENG. WITH SFI, TEST / REPL. .4 A2/A3/A7/A8/67/68
92/93/94
.5 A4/A9
IGNITION COIL(S)
----------------
15-2013 * IGNITION COIL - ONE, REPL. .0 C6/M4/M8
(AFTER TEST) .1 H0
(SEE ALSO 15-2290) B3/B4/B7/B8/B9/C2
C3/E2/E3/G1/G2/62
63/64/65/89
.2 C5/21/22/23
.3 10/25
A1/B1/B2/C7/S1/S2
S3/S4/S5/S6/T1/T2
T3/T4/T5/U1/U2/U3
U4/41/44/45/47/51
52/53/54/55/71/72
73/74/75/82/83/84
85/88/91/92/93/94
95/96/97
.4 P5
.5 P1/P2/P3/P4/P6/P7
P8/P9/Q0/67/68
.6 N0
A2/A3/A7/A8/E4/E6
E7/E8/E9/F1/F2/G3
G4/J1/M1/M2/M3/M5
M6/M7/M9/R1/R2/98
.7 A4/A9
1.8 C1/C4
15-013 EFF DATE: 11-01-03
+ 15-TTT
-
15-2043 * IGNITION COILS - ALL, REPL. .0 M4/M8/N2/P1
(AFTER TEST) .2 B1/B2/C2/C3/E3/G1
(SEE ALSO 15-2290) G2/62/63/64/65/89
95
.5 Q1
.6 P5/U1/U4
.7 B3/B7/B8/C5/E2/E6
E7/E8/E9/G3/G4/H1
H3/Q3/T1/T4/96
.8 E4/F1/F2/H2/H4/H5
H6/J1/M1/M2/M3/M5
M6/M7/M9/N1/N3/N5
T2/T3/T5/U2/U3/67
68/93/98
.9 B4/B9/R1/R2/S1/S2
S3/S4/S5/S6/97
1.1 P2/P3/P4/P6/P7/P8
P9/Q2/Q4
1.2 A2/A3/A4/A7/A8/A9
94
1.8 C1/C4
15-2053 IGNITION COIL(S) COVER, REPL. .1 A1/A2/A3/A4/A7/A8
A9/26/27/41/47/82
83/84/85/88/91/92
93/94
15-2063 IGNITION COIL RESISTOR(S), REPL. .3 10/20
(AFTER TEST) 51/52/54/71/72/73
15-014 EFF DATE: 11-01-03
+ 15-TTT
-
DIAGNOSTIC SOCKET (X11), REPL.
-----------------------
15-2073 DIAGNOSTIC SOCKET (X 11), REPL. .4 B0/25/40/50/70/90
A1/A2/A3/A4/A7/A8
A9/E3/11/12/15/35
36/37/62/63/64/65
67/68/81/82/83/85
86/87/88/89
IGNITION CONTROL MODULE
-----------------------
15-2093 DISTRIBUTOR IGNITION CONTROL MODULE, REPL. .3 10/25
(AFTER TEST) A1/A2/A3/A4/A7/A8
A9/M8/41/44/45/47
51/52/53/54/55/67
68/71/72/73/74/75
82/83/84/85/88/91
92/93/94
15-015 EFF DATE: 11-01-03
+ 15-TTT
-
CRANKSHAFT POSITION SENSOR
--------------------------
15-2133 * CRANKSHAFT POSITION SENSOR(S) - IGNITION SYST., REPL. .0 A4/A9/B4/B9/C6/M4
(AFTER TEST) .0 94
.3 E3/P5/Q3/T1/T2/T4
T5/U1/U2/U3/U4
.4 N0
A2/A3/A7/A8/B3/B7
B8/C5/E1/E2/E4/E5
E6/E7/E8/E9/F1/F2
G3/G4/H1/H2/H3/H4
H5/H6/J1/M1/M2/M3
M5/M6/M7/M9/P1/P2
P3/P4/P6/P7/P8/P9
Q2/Q4/S1/S4/41/44
45/47/98
.5 Q1/R1/T3/26/27/62
63/64/65/74/75/82
83/84/85/88/89/91
95
.6 R2/67/68/71/72/73
92/93/96
.7 S2/S3/S5/S6
.9 M8
1.0 15
1.2 97
1.3 A1/B1/B2/C1/C4/C7
G1/G2
1.9 C2/C3
15-2134 CRANKSHAFT POSITION SENSOR - IGNITION SYST., REPL. 2.2 B4/B9
(INTAKE MANIFOLD REMOVED)
15-2138 * CRANKSHAFT POSITION SENSOR - DIESEL FUEL INJ., REPL. .6 61
(AFTER TEST)
15-016 EFF DATE: 11-01-03
+ 15-TTT
-
CAMSHAFT POSITION SENSOR
------------------------
15-2143 * CAMSHAFT POSITION SENSOR - IGNITION SYST., REPL. .3 C1/C4/C7
(AFTER TEST) .4 A2/A3/A7/A8/67/68
.5 A4/A9/C2/C3/62/63
64/65/89
.8 A1/B1/B2
CAMSHAFT HALL EFFECT SENSOR, REPL.
---------------------------
15-2148 CAMSHAFT HALL EFFECT SENSOR - IGNITION SYST., REPL. .0 C6/M4/M8
(AFTER TEST) .2 B3/B7/B8/C5/E2/G1
G2/G3/G4/H1/H2/H3
H4/H5/H6/P1/P2/P3
P4/P6/P7/P8/P9/Q2
Q4/S4/S5/S6/96/98
.3 N0
E3/E4/E6/E7/E8/E9
F1/F2/J1/M1/M2/M3
M5/M6/M7/M9/P5/Q1
Q3/R1/S1/S2/S3/T1
T2/T4/T5/U1/U2/U3
U4
.4 B4/B9/97
.7 R2
.8 T3
15-2150 CAMSHAFT HALL SENSOR - LEFT CYLINDER HEAD IGN. SYST., REPL. .9 M8
15-2151 CAMSHAFT HALL SENSOR - RIGHT CYLINDER HEAD IGN. SYST., REPL. .9 M8
15-017 EFF DATE: 11-01-03
+ 15-TTT
-
REFERENCE RESISTOR
------------------
15-2153 REFERENCE RESISTOR (R16/1,2) - IGNITION SYSTEM, REPL. .1 25/90
(AFTER TEST) A1/A2/A3/A4/A7/A8
A9/B1/B2/B3/B4/B7
B8/B9/15/62/63/64
65/67/68/71/72/73
74/75/82/83/84/85
88/89
.2 45/47
VACUUM LINES - IGNITION SYSTEM
------------
15-2173 VACUUM LINE(S) - IGNITION SYSTEM, REPL. .1 26/27/82/83/84/85
(AFTER TEST) 88
.2 10/20
41/47/51/52/53/54
55/71/72/73
15-2174 KNOCK SENSOR, FRONT LEFT CYL. HEAD - IGNITION SYSTEM, R & R .3 M8
15-2175 KNOCK SENSOR, REAR LEFT CYL. HEAD - IGNITION SYSTEM, R & R .3 M8
15-2176 KNOCK SENSOR, FRONT RIGHT CYL. HEAD - IGNITION SYSTEM, R & R .0 M8
15-2177 KNOCK SENSOR, REAR RIGHT CYL. HEAD - IGNITION SYSTEM, R & R 1.5 M8
15-018 EFF DATE: 11-01-03
+ 15-TTT
-
KNOCK SENSOR(S) - IGNITION SYSTEM
---------------
15-2183 * IGN. KNOCK SENSOR (ONE), REPL. .0 C6
(AFTER TEST) .8 C1/C4/C7/G1/G2/P5
Q3
1.3 A1/B1/B2/62/63/64
65/89/95
1.6 B3/B7/B8/E3
1.7 U1/U2/U3/U4
1.8 C2/C3/E2/E6/E7
1.9 96
2.0 Q1
2.2 T1/T4
2.3 C5/E8/E9/H1/H3/P1
P2/P3/P4/P6/P7/P8
P9/Q2/Q4/S1/S4/T2
T5
2.4 67/68
2.5 E4/F1/H2/S2/S3/S5
S6/98
2.8 A2/A3/A7/A8/92/93
3.4 T3
15-2184 IGN. KNOCK SENSOR, ONE - (INTAKE MANIFOLD REMOVED), REPL. .7 A4/A9
.9 94/97
1.5 B4/B9
15-019 EFF DATE: 11-01-03
+ 15-TTT
-
15-2188 * IGN. KNOCK SENSORS - BOTH, REPL. .0 C6/M4/M8/M9/N2/N4
(AFTER TEST) .0 R2
.8 H1/H2/H4/H5/H6
1.0 E2
1.5 B1/B2/95
1.7 U1/U4
1.8 R1/S1/S4/U2/U3
1.9 E6/E7/E8/E9/G3/G4
S2/S3/S5/S6
2.1 E4/F1/F2/J1/M1/M2
M3/M5/M6/M7/N1/N3
P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4
2.3 T1/T2/T4/T5
2.4 C5/H3
2.5 E3/96
2.6 98
3.5 T3
3.8 B3/B7/B8
15-2189 IGN. KNOCK SENSORS, BOTH - (INTAKE MANIFOLD REMOVED), REPL. .0 C6/M4/M8/R2
.2 P3/P4/Q4
.3 N0
C5/E2/E4/E6/E7/E8
E9/F1/F2/G3/G4/H1
H2/H3/H4/H5/H6/J1
M1/M2/M3/M5/M6/M7
M9/P1/P2/P6/P7/P8
P9/Q2/R1/S1/S2/S3
S4/S5/S6/T1/T2/T3
T4/T5/U1/U2/U3/U4
98
1.3 A4/A9
2.3 B4/B9
15-020 EFF DATE: 11-01-03
+ 15-TTT
-
ENGINE SYSTEMS (MAS) CONTROL MODULE
-----------------------------------
15-2193 ENGINE SYSTEMS (MAS) CONTROL MODULE, REPL. .2 26/27/45/74/75/82
(AFTER TEST) 83/85/88/91/92
15-2290 ADDITIONAL TO IGNITION COIL, REPLACE .0 C7
(VEHICLES WITH A/C) .3 C1/C4
15-2320 ADDITIONAL TO CRANKSHAFT POSITION SENSOR,REPLACE 1.2 C1/C4/C7
(VEHICLES WITH CRUISE CONTROL)
15-2408 IGNITION COIL MODULE - LEFT (AFTER TEST), R & R/ REPL IF NEC 1.1 M4/M8/N2/N4
15-2409 IGNITION COIL MODULE - RT.(AFTER TEST), R & R/ REPL IF NEC 1.1 M4/M8/N2/N4
15-2410 IGNITION COIL MODULE - BOTH (AFTER TEST), R & R/ REPL IF NEC 1.9 M4/M8/N2/N4
15-021 EFF DATE: 11-01-03
+ 15-TTT
-
HIGH VOLTAGE DISTRIBUTOR, CHECK / ADJ. / R & R>/a>
------------------------
15-2810 * H.V. DISTRIBUTOR (CAMSHAFT DRIVEN) - ONE, CHECK .2 92
.3 26/27/74/75/82/83
84/85/88/91
.4 45
15-2820 * H.V. DISTRIBUTOR BASIC ADJUSTM., CHECK / ADJ.IF REQ. .5 15/71/72/73
15-3010 * H.V. DISTRIBUTOR (WITH VAC. ADVANCE), R & R .3 44
.4 20
41/47
.6 11/12/13/14/51/52
53/54/55
15-3020 * H.V. DISTRIBUTOR (W/OUT VAC. ADVANCE), R & R .8 15/71/72/73
15-022 EFF DATE: 11-01-03
+ 15-TTT
-
HIGH VOLTAGE DISTRIBUTOR PARTS, REPL.
------------------------------
15-3213 * H.V. DISTRIBUTOR CAP, ONE - ENG. WITH CFI, REPL. .2 10/20
(AFTER TEST) 41/44/47/51/52/53
54/55/71/72/73/92
.3 26/27/45/74/75/82
83/84/85/88/91
15-3233 H.V. DISTRIBUTOR ROTOR AND/OR BRUSH - ENG. WITH CFI, REPL. .1 20/25
(AFTER TEST) 41/44/45/47/51/52
53/54/55/74/75/82
83/84/85/88/91
.2 10
71/72/73/92
15-3253 H.V. DISTRIBUTOR VACUUM UNIT, REPL. .3 20
(AFTER TEST) 41/47/51/52/53/54
55/71/72/73
.4 10
15-3263 H.V. DISTRIBUTOR POINTS, REPL. .2 20
(AFTER TEST) 13/14
15-3273 * EFI IMPULSE CONTACT POINTS - ON H.V. DISTRIBUTOR, REPL. .6 13/14
(AFTER TEST)
15-3283 IGNITION CABLE CONNECTORS TO H.V. DISTRIBUTOR - ALL, REPL. .3 20/25
41/44/45/47/74/75
82/83/84/85/88/91
.4 11/12/15/51/52/53
54/55/71/72/73/92
15-023 EFF DATE: 11-01-03
+ 15-TTT
-
15-3293 IGNITION CABLE CONNECTOR TO H.V. DISTRIBUTOR - ONE, REPL. .2 20/25
11/12/15/41/44/45
47/51/52/53/54/55
71/72/73/74/75/82
83/84/85/88/91/92
15-3313 H.V. DISTRIBUTOR CAP COVER - TOP, REPL. .1 26/27/45/74/75/82
83/84/85/88
15-3323 * H.V. DISTRIBUTOR CAP COVER - BOTTOM, REPL. .3 26/27/45/74/75/82
83/84/85/88
TRANSM. OVERLOAD PROTECTION SWITCH, TEST / REPL.
----------------------------------
15-3611 * TRANSM. OVERLOAD PROTECTION SWITCH (S65/..)-TEST, PERFORM .0 C2/C3
.3 A0
B1/B2/E2/62/63/64
65/67/68/85/89/91
92/93/94/95
15-3612 * TRANSM. OVERLOAD PROTECTION SWITCH (S65/..), REPL. .0 C2/C3
(AFTER TEST) .3 A0
B1/B2/E2/62/63/64
65/67/68/85/89/91
92/93/94/95
15-3625 WIRING HARNESS - GENERATOR AND STARTER-TEST, PERFORM .0 R1/R2
15-3626 WIRING HARNESS - GENERATOR AND STARTER, REPLACE 1.5 R1/R2
(AFTER TEST)
15-024 EFF DATE: 11-01-03
+ 15-TTT
-
DIESEL PREGLOW SYSTEM TESTS & REPLACEMENTS
------------------------------------------
15-4000 * DIESEL PREGLOW SYSTEM, CHECK / DETERM. CONDITION .5 30
A5/E5/42/43/46/56
57/61/78/79/81/86
87
15-4110 * DIESEL GLOW PLUGS - ALL, R & R / REPL. IF REQ. .0 A5
.5 31
.6 32/33/34/35/36/37
56
.7 42
.8 43
.9 46
1.5 86
1.7 81/87
1.8 57/78/79
2.5 E1/E5/61
15-4113 DIESEL GLOW PLUGS, ALL - (INTAKE MANIFOLD REMOVED), REPL. .3 42
.4 E1/E5/43/46
.6 A5/57/61/78/79/81
86/87
15-4120 DIESEL GLOW PLUG - ONE, R & R / REPL. IF REQ. .2 30
(INTAKE MANIFOLD REMOVED) E1/E5/56
.3 A5/42/43/46/57/61
78/79/81/86/87
15-4332 * PREGLOW TIME RELAY MODULE - DIESEL PREGLOW SYSTEM, REPL. .2 30
(AFTER TEST) A5/42/43/46/56/57
61/78/79/81/86/87
.3 E1/E5
15-025 EFF DATE: 11-01-03
+ 15-TTT
-
15-4352 * FUSE - FOR DIESEL PREGLOW SYSTEM, REPL. .1 30
A5/E5/42/43/46/56
57/61/78/79/81/87
15-4382 GLOW PLUG LINE(S) & INSULATOR(S) - DIESEL PREGLOW, REPL. .3 31/32/33/34
15-4402 WIRING HARNESS FOR GLOW PLUGS - DIESEL PREGLOW SYST., REPL. .8 42
(AFTER TEST) 1.0 43/46/86
1.1 A5/57/78/79
1.2 81/87
1.4 E1
3.1 E5
15-4403 WIRING HARNESS FOR GLOW PLUGS - DIESEL PREGLOW SYST., REPL. .0 E1/E5
(INT. MANIFOLD REMOVED) 1.2 61
15-026 EFF DATE: 11-01-03
+ 15-TTT
-
GENERATOR, TEST / R & R / REPL.
---------
15-5010 * GENERATOR WITH REGULATOR AND CABLES-TEST, PERFORM .4 10/20/50/70
.5 A0/B0/C0/H0/M0/N0
25/40/60/80/90
G1/G2/J1/P0/Q0/S1
S2/S3/S4/S5/S6
.6 E0/30
F1/F2/G3/G4
.9 U0
1.0 T1/T2/T3/T4/T5
1.2 R0
15-027 EFF DATE: 11-01-03
+ 15-TTT
-
15-5030 * GENERATOR, R & R .0 C6/U3/U4
.5 30
C1/C4/C7/G1/G2/74
75
.6 10/50
A5/41/42/43/45/47
61/71/72/73/78/79
.7 25/80
U1/62/63/64/65
.8 20
A1/B1/B2/C2/C3/C5
E1/E2/E3/E6/E7/E8
E9/F2/G3/G4/H1/H3
T1/T4/46/91/95/98
.9 S1/S4/92/93/96
1.0 E4/H2/H4/H5/H6/44
1.1 P5/Q3/R1
1.2 U2
1.3 E5/P1/P2/P3/P4/P6
P7/P8/P9/Q2/Q4/67
68/94/97
1.4 T2/T5
1.5 Q1
1.6 A2/A3/A4/A7/A8/A9
B3/B4/B7/B8/B9
1.8 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5
1.9 S2/S3/S5/S6
2.0 R2
2.1 T3
2.6 F1
3.1 M8
4.6 M4/N2/N4
15-028 EFF DATE: 11-01-03
+ 15-TTT
-
15-5035 * GENERATOR - (ENGINE REMOVED), R & R .0 M4
.2 G1/G2
.3 A0/B0/C0/E0/H0/N0
25/40/60/80/90
F1/F2/G3/G4/J1/M1
M2/M3/M5/M6/M7/M9
P5/Q1/Q3/R1/R2/S1
S2/S3/S4/T1/T2/T3
T4/T5/U1/U2/U3/U4
56/57/74/75/78/79
.4 10
M8/P1/P2/P3/P4/P6
P7/P8/P9/Q2/Q4/51
52/53/54/55/71/72
73
15-029 EFF DATE: 11-01-03
+ 15-TTT
-
15-5070 * GENERATOR, REPL. .0 C6/T4/T5/U3/U4
.5 C1/C4/C7/G1/G2/74
75
.6 30
.7 10/50/80
A5/26/27/61/71/72
73/78/79
.8 A1/B1/B2/C2/C3/C5
E1/E2/E3/E6/E7/E8
E9/G3/G4/H1/H3/U1
41/42/43/45/47/62
63/64/65/91/95/98
.9 S1/S4/T1/46/92/93
96
1.0 20
E4/F1/F2/H2/H4/H5
H6
1.1 P5/Q3/R1
1.3 E5/P1/P2/P3/P4/P6
P7/P8/P9/Q2/Q4/U2
44/67/68/94/97
1.5 Q1/T2
1.6 A2/A3/A4/A7/A8/A9
B3/B4/B7/B8/B9
1.8 J1/M1/M2/M3/M5/M6
M7/M9/N1/N3/N5
1.9 S2/S3/S5/S6
2.0 R2
2.1 T3
3.1 M8
4.6 M4/N2/N4
15-030 EFF DATE: 11-01-03
+ 15-TTT
-
15-5075 * GENERATOR - (ENGINE REMOVED), REPL. .0 M4
.3 A0/B0/C0/E0/H0/N0
25/60/80/90
F1/F2/G1/G2/G3/G4
J1/M1/M2/M3/M5/M6
M7/M9/P1/P2/P5/Q1
Q2/Q3/R1/R2/S1/S2
S3/S4/S5/S6/T1/T2
T3/T4/T5/U1/U2/U3
U4/41/43/45/46/47
.4 M8/P3/P4/P6/P7/P8
P9/Q4/74/75
.5 10/50
44/71/72/73/78/79
15-5700 GENERATOR PULLEY, REPLACE .0 M4/M8
.6 N0
J1/M1/M2/M3/M5/M6
M7/M9/U1/U2/U3/U4
.9 T3
1.0 R1/R2
15-031 EFF DATE: 11-01-03
+ 15-TTT
-
GENERATOR PARTS, REPL.
---------------
15-5710 GENERATOR PULLEY - (GENERATOR REMOVED), REPL. .2 00
15-5720 GENERATOR PULLEY - (ENGINE REMOVED), REPL. .3 00
15-5760 * VOLTAGE REGULATOR, REPL. .0 N2/N4
(AFTER GENERATOR WITH REGULATOR AND CABLE TEST) .3 20/25/30/60/80
41/42/43/45/47/56
57/74/75/78/79/91
95
.5 A0/B0
46
.6 10
T1/T2/T3/T4/T5/U1
U2/U3/U4/51/52/53
54/55/71/72/73/92
93/94/96/97/98
.8 44
1.0 E1/E2/E3/E5/E6/E7
E8/E9/R1/R2/S1/S4
1.2 E4/F0/N1/N3/N5/S2
S3/S5/S6
15-5761 VOLTAGE REGULATOR (VEH. WITH GENERATOR REAR COVER), REPL. .6 60
26/27/81/82/83/84
85/86/87/88/89
15-032 EFF DATE: 11-01-03
+ 15-TTT
-
15-5770 VOLTAGE REGULATOR - (GENERATOR REMOVED), REPL. .2 A0/B0/C0/E0/G0/H0
M0/N0/25/50/60/70
90
F1/F2/J1/P0/Q1/Q2
Q3/Q4/S1/S2/S3/S4
S5/S6/86/89
.3 R1/R2/T1/T2/T3/T4
T5/U0
15-5780 * CONDENSER/NOISE SUPPRESSOR FOR GENERATOR, REPL. .0 P0/Q0
.2 20/25/30/50/70/80
11/12/15/41/42/43
45/47/91
.3 A0
46/92/93/94
.6 13/14
.7 44
15-5785 GENERATOR REAR COVER, REPL. .0 N2/N4/P0/Q0
.2 E0/60
F0/89
.8 R1/R2
1.2 N1/N3/N5
15-033 EFF DATE: 11-01-03
+ 15-TTT
-
WIRING HARNESS TO GENERATOR, REPL.
---------------------------
15-6052 * WIRING HARNESS - TO GENERATOR, REPL. .0 A0/B0/C0/E0/G0/H0
(AFTER GENERATOR WITH REGULATOR AND CABLE TEST) .0 M4/M8/T1/T2/T3/U0
.4 25/60/80
41/42/43/45/47/57
78/79
.5 74/75
.6 46
.7 90
.8 44
1.4 S1/S2/S3/S4/S5/S6
1.6 N0
J1/M1/M2/M3/M5/M6
M7/M9/P0/Q0
15-034 EFF DATE: 11-01-03
+ 15-TTT
-
GENERATOR CARRIER & SUPPORT
----------------------------
15-6212 GENERATOR CARRIER - (GENERATOR REMOVED), REPL. .0 A2/A3/A4/A7/A8/A9
.0 B3/B4/B7/B8/B9/C5
.0 C6/S2/S3/S5/S6/94
.0 97
.2 25/60
45/74/75/82/83/84
85/88/89
.3 G0/H0/M0/N0/10/20
30
A5/C1/C4/C7/E1/E2
E3/E4/E5/E6/E7/E8
E9/F1/F2/J1/P0/Q0
S1/S4/T1/T2/T3/T4
T5/42/43/46/56/57
78/79/81/86/87/98
.5 C2/C3/41/44/47/51
52/53/54/55/71/72
73
.8 A1/B1/B2/91/95
1.1 92/93/96
15-6700 * GENERATOR SUPPORT BRACKET, R & R / REPL. IF REQ. .0 67/68
1.1 41/44/47
1.3 26/27/62/63/64/65
74/75/82/83/84/85
88/89
1.6 45
15-6702 * GENERATOR SUPPORT BRACKET - (GENERATOR REMOVED), R & R/REPL. .4 26/27/41/44/47/62
63/64/65/67/68/74
75/82/83/84/85/88
89
.5 E2
1.0 45
15-035 EFF DATE: 11-01-03
+ 15-TTT
-
STARTER MOTOR
-------------
15-7020 * STARTER MOTOR, TEST .4 00
15-7100 * STARTER MOTOR, R & R .0 C6/U3/U4
.7 C5/E1/E2/E3/E5/G3
G4/H1/H2/H3/H4/H5
H6/T3/U1
.8 Q1/T1/61
.9 A1/A2/A3/A4/A7/A8
A9/B1/B2/B3/B4/B7
B8/B9/C1/C4/C7/G1
G2/26/27/62/63/64
65/81/82/83/84/85
86/87/88/89
1.0 90
M1/M2/M3/M5/M9/N1
N3/N5/Q3/S5/S6
1.1 51/52/53/54/55/67
68/71/72/73
1.2 R1/41/42/43/46/47
1.3 P5/U2/74/75
1.4 R2
1.5 T2
1.6 E4/E6/E9/F1/F2/45
1.7 A5/56/57/78/79
1.8 C2/C3/M4/N2/N4/44
1.9 S4/T4/T5
2.0 M8
2.1 E7/E8/J1/M6/M7
2.2 S1/S2/S3
2.3 P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4
2.4 10
15-036 EFF DATE: 11-01-03
+ 15-TTT
-
15-7109 STARTER MOTOR, R & R .0 M8
(ENGINE REMOVED) .3 N0
J1/M1/M2/M3/M4/M5
M6/M7/M9/R1/R2/T1
T2/T3/T4/T5/U0
15-7170 * STARTER MOTOR, REPL. .0 C6/U3/U4
.7 C5/E1/E2/E3/E5/E7
E8/G3/G4/H1/H2/H3
H4/H5/H6/T3/U1
.8 T1/32/33/34/61
.9 A1/A2/A3/A4/A7/A8
A9/B1/B2/B3/B4/B7
B8/B9/C1/C4/C7/G1
G2/26/27/62/63/64
65/81/82/83/84/85
86/87/88/89
1.0 90
M1/M2/M3/M5/M9/N1
N3/N5/Q3/S5/S6
1.1 31/51/52/53/54/55
67/68/71/72/73
1.2 R1/41/42/43/46/47
1.3 P5/Q1/U2/22/23/74
75
1.4 R2
1.5 T2
1.6 E4/E6/E9/F1/F2/45
1.7 A5/21/35/36/37/56
57/78/79
1.8 C2/C3/M4/N2/N4/44
1.9 T4/T5
2.1 J1/M6/M7
2.2 S1/S2/S3/S4
2.3 M8/P1/P2/P3/P4/P6
P7/P8/P9/Q2/Q4
2.4 10
15-037 EFF DATE: 11-01-03
+ 15-TTT
-
15-7175 * STARTER MOTOR - (WITH TRANSMISSION REMOVED), REPL. .2 B0/C0/E0/G0/H0/M0
N0/25/90
A1/A2/A3/A4/A7/A8
A9/F1/F2/J1/41/45
47/62/63/64/65/67
68/74/75/82/83/84
85/88/89
.3 R1/R2/T3/U1/U4
.4 P5/Q1/Q3/T1/T4
.5 10
A5/42/43/44/46/51
52/53/54/55/56/57
61/78/79/81/86/87
.9 S1/S2/S3/S4/S5/S6
U2/U3
1.0 P1/P2/P3/P4/P6/P7
P8/P9/Q2/Q4/T2/T5
15-038 EFF DATE: 11-01-03
+ 15-TTT
-
STARTER CABLE RUBBER BOOT
-------------------------
15-7780 * STARTER CABLE RUBBER BOOT, REPL. .3 26/27/42/43/45/46
56/71/72/73/82/83
84/88
.4 A0/B0/10/90
51/52/53/54/55/62
63/64/65/67/68/85
89
.5 E0/M0/N0
F0/57/61/78/79/81
86/87
.7 74/75
.8 41/44/47
15-039 EFF DATE: 11-01-03
+ 15-XXX
-
15 0000 < JOBS IN GROUP 15 INCLUDE OPERATIONS AS REQ. FOR: >
SYNCHRONIZE/CODE/RESET COMPONENTS DUE TO REPAIRS
<JOBS IN GROUP 15 DO NOT INCLUDE OPERATION(S) FOR: >
ENGINE COMPARTMENT PANEL(S) - BOTTOM, R & R WHERE REQ.
0______________________________________________________________________________________________________
0 15 1010 +INCLUDES:
<140 MODEL: >
AIR COLLECTOR DUCT, R & R <(120 ENG.)>
WIRING DUCT AT PARTITION, LOOSEN / REINSTALL <(120 ENG.)>
0______________________________________________________________________________________________________
15-X001
+ 15-XXX
-
15 1250 +INCLUDES:
TESTING ELECTRONIC IGN. SYSTEM WITH VARIABLE CHARACTERISTICS
- VOLTAGE SUPPLY AT DIAGNOSTIC PLUG
- STARTER RING GEAR POSITION SENSOR
- IGNITION COIL
- THROTTLE BODY SWITCH
- REFERENCE RESISTOR
- WIRING BETWEEN CONTROL MODULE & RESISTOR PLUG
- TRANSM. OVERLOAD PROTECTION
- TEMPERATURE SENSOR
- VACUUM SUPPLY/ADVANCE
0______________________________________________________________________________________________________
0 15 1905 +INCLUDES:
SOCKET BOX, C & D FOR TESTING
0______________________________________________________________________________________________________
0 15 1906 +INCLUDES:
ESTABLISH POSSIBLE CAUSE/REMEDY WHEN NOMINAL VALUES ARE NOT
- ACHIEVED
0______________________________________________________________________________________________________
15-X002
+ 15-XXX
-
15 1912 +INCLUDES:
1914 DTC, ERASE AFTER REPAIR
1918
1920
3611
3612
0______________________________________________________________________________________________________
0 15 1916 +INCLUDES:
DTC, ERASE AFTER REPAIR
+DOES NOT INCLUDE:
TEST STEP 8.1
0______________________________________________________________________________________________________
0 15 1922 +INCLUDES:
SPARK PLUG WIRE COVERS, D & C AS NEC.
SPARK PLUG CONNECTOR (ONE), D & C
OSCILLOSCOPE PICTURE, EVALUATE
0______________________________________________________________________________________________________
0 15 1924 +INCLUDES:
SPARK PLUG CABLES & COVERS, D & C
SPARK PLUG CONNECTORS, D & C
HIGH TENSION IGNITION CABLES - ALL, TEST WITH TESTER
15-X003
+ 15-XXX
-
<104/111 ENG. WITH HFM-SFI INCLUDES ADDITIONALLY: >
AIR INT. DUCT WITH MASS AIR FLOW SENSOR, R & R
+AFTER INSPECTION:
SPARK PLUG CONNECTOR(S), REPL.
0______________________________________________________________________________________________________
0 15 1925 +INCLUDES:
1926 HEADLAMP REAR COVER - L/SIDE, D & C <(140 WITH ENG. 119)>
SPARK PLUG WIRES & COVERS, D & C
SPARK PLUG CONNECTORS, D & C
HIGH TENSION IGNITION CABLES - ALL, TEST WITH TESTER
+AFTER INSPECTION:
SPARK PLUG CONNECTORS, REPL.
0______________________________________________________________________________________________________
0 15 1928 +INCLUDES:
DISTRIBUTOR CAP & ROTOR, D & C
DISTRIBUTOR CAP & ROTOR, TEST WITH MULTIMETER
0______________________________________________________________________________________________________
0 15 1929 +INCLUDES:
1930 DISTRIBUTOR CAP & ROTOR, D & C
DISTRIBUTOR CAP & ROTOR, TEST WITH MULTIMETER
15-X004
+ 15-XXX
-
15 2013 +INCLUDES:
2043 COIL COVER(S), R & R (WHERE APPLICABLE)
<140 MODEL INCL. ADDITIONALLY: >
HEADLAMP REAR COVER - L/SIDE, D & C <(119 ENG.)>
HEADLAMP REAR COVER(S), R & R <(120 ENG. WITH LH-SFI)>
<202 MODEL INCLUDES ADDITIONALLY: >
COIL SUPPORTS, D & C
COILS - ALL, R & R <(C220)>
0______________________________________________________________________________________________________
15-X005
+ 15-XXX
-
15 2133 +INCLUDES:
<129/140 MODELS: >
INT. MANIFOLD, R & R <(120 ENG.)>
SECOND SENSOR, REPL. IF NEC. <(120 ENG.)>
STARTER MOTOR, LOOSEN / REINSTALL <(104 ENG.)>
CABLE HOLDERS/CLAMPS, D & C <(104)>
WIRING DUCT AT PARTITION, LOOSEN / REINSTALL <(119 ENG.)>
<202 MODEL: >
STARTER MOTOR, R & R <(C220/230/280 WITH IN-LINE CYL.)>
CRUISE ACTUATOR, D & C <(C220/230)>
<210 MODEL: >
STARTER MOTOR, R & R <(104 ENG.)>
0______________________________________________________________________________________________________
0 15 2138 +INCLUDES:
COVERINGS, D & C AS NEC.
SENSOR, R & R
0______________________________________________________________________________________________________
15-X006
+ 15-XXX
-
15 2143 +INCLUDES:
<ENG. 104 WITH LH-SFI: >
VALVE COVER, R & R
DISTANCE BETWEEN SENSOR & CONTACT PICKUP, MEASURE
SENSOR, R & R / DETERM. SPACING/SPACER
<111/119 ENGINES: >
DISTANCE FROM HOUSING TO CAMSHAFT, MEASURE
SENSOR, R & R / DETERMINE SPACER
0______________________________________________________________________________________________________
0 15 2183 +INCLUDES:
<129/140 MODELS WITH ENG. 119 AND LH-SFI: >
ENG. SUPPORT ARM(S), D & C
BOTH KNOCK SENSORS ON SAME WIRING STRING, R & R
<129/140 MODELS WITH ENG. 119 AND ME-SFI: >
ENG. SUPPORT ARM, D & C
<202 MODEL: >
STARTER MOTOR, R & R <(104 ENG.)>
INT. MANIFOLD, R & R <(112 ENG.)>
<210 MODEL: >
STARTER MOTOR, R & R <(104 ENG.)>
INT. MANIFOLD, R & R <(112 ENG.)>
15-X007
+ 15-XXX
-
0______________________________________________________________________________________________________
0 15 2188 +INCLUDES:
<129/140 MODELS: >
AIR CLEANER, R & R
ENG. SUPPORT ARM - BOTH SIDES, D & C <(119 ENG.)>
ENG. SUPPORT ARM - L/SIDE, D & C <(104 ENG. WITH HFM-SFI)>
<202/210 MODELS: >
INTAKE MANIFOLD, R & R <(112 ENG.)>
0______________________________________________________________________________________________________
0 15 2810 +INCLUDES:
DISTRIBUTOR CAP, R & R
BRUSH AND CONTACTS, CHECK VISUALLY
RESISTORS, TEST
DISTRIBUTOR ROTOR, TEST
+AFTER INSPECTION:
DISTIBUTOR ROTOR, REPL.
15-X008
+ 15-XXX
-
15 2820 +INCLUDES:
DISTRIBUTOR CAP, R & R
BRUSH AND CONTACTS, CHECH VISUALLY
DISTRIBUTOR ROTOR, TEST / REPL. IF REQ.
FAN COUPLING, R & R
ENGINE, SET TO TDC ON NO. 1 CYL.
ADJUSTMENT, CHECK WITH GAUGE
0______________________________________________________________________________________________________
0 15 3010 +INCLUDES:
HIGH VOLTAGE DISTRIBUTOR, REPL.IF REQ.
ENGINE, SET TO TDC ON NO. 1 CYL.
0______________________________________________________________________________________________________
0 15 3020 +INCLUDES:
DISTRIBUTOR CAP, R & R
FAN COUPLING, R & R
ENGINE, SET TO TDC ON NO. 1 CYL.
BASIC ADJUSTMENT, CHECK / CORRECT
+AFTER INSPECTION:
HIGH VOLTAGE DISTRIBUTOR, REPL. IF REQ.
0______________________________________________________________________________________________________
0 15 3213 +INCLUDES:
+AFTER INSPECTION:
DISTRIBUTOR CAP COVER LOWER PART, REPL. (WHERE APPLICABLE)
DISTRIBUTOR ROTOR, REPL.
15-X009
+ 15-XXX
-
15 3273 +INCLUDES:
HIGH VOLTAGE DISTRIBUTOR, R & R
0______________________________________________________________________________________________________
0 15 3323 +INCLUDES:
+AFTER INSPECTION:
DISTRIBUTOR CAP, REPL.
0______________________________________________________________________________________________________
0 15 4000 +INCLUDES:
<ENGINES 616/617 UP TO 1980: >
FUSE AT FIREWALL, CHECK
VOLTAGE AT REAR GLOW PLUG, CHECK
INCOMING AND OUTGOING VOLTAGE ON ALL GLOW PLUGS, CHECK
PLUG ON PREGLOW TIME RELAY, D & C
MEASURE VOLTAGE AT RELAY COUPLING
PREGLOW SYSTEM WIRE HARNESS AND CONNECTORS, CHECK
<ENGINES 601/602/603/616/617: >
VOLTAGE AT RELAY MODULE TERMINAL 30, CHECK
VOLTAGE AT RELAY 4-POLE COUPLING, SOCKET 1 TO GROUND, CHECK
VOLTAGE AT RELAY 4 POLE COUPLING, BETWEEN SOCKETS 1&4, CHECK
VOLTAGE DRAW OF GLOW PLUGS, CHECK
<ENGINE 606: >
DETERMINE TEST CONDITION ACCORDING TO COMPLAINT CHART
PREGLOW SYST. TEST PROGRAM, PERFORM
15-X010
+ 15-XXX
-
15 4110 +INCLUDES:
<TURBO DIESEL: >
W/WASHER RESERVOIR, R & R <(EXCEPT 300D 2.5 TURBO)>
CHARGED AIR PIPE ABOVE VALVE COVER, R & R
FUEL LINES FOR CYL. 1 TO 3, R & R
ACCELERATOR LINKAGE/BEARING AT INT. MANIFOLD, D & C
<606 ENG.: >
RESONANCE INT. MANIFOLD, R & R
DIESEL FUEL HEATER/THERMOSTAT, R & R
DIESEL INJECTOR LINES, R & R
0______________________________________________________________________________________________________
0 15 4332 +INCLUDES:
<210 MODEL: >
W/WASHER CONTAINER, R & R
0______________________________________________________________________________________________________
0 15 4352 +INCLUDES:
VISUAL/OPERATIONAL INSPECTION
0______________________________________________________________________________________________________
0 15 5010 +INCLUDES:
BELT, CABLE CONNECTIONS & CHARGE CONTROL LIGHT, VISUAL CHECK
SPECIFIC GRAVITY OF EACH BATTERY CELL, CHECK
BATTERY DISCHARGE CURRENT, CHECK WITH IGNITION OFF
BATTERY LOAD TEST, PERFORM
15-X011
+ 15-XXX
-
REGULATOR VOLTAGE AT SPECIFIED ENGINE RPM/SPECIFIC GRAVITY/
- BATTERY LOAD AND TEST TIME, CHECK WITH VOLTMETER
CHARGING CURRENT OF GENERATOR AT SPECIFIED RPM & LOAD ON
- BATTERY, CHECK / OBSERVE REGULATING VOLTAGE
GENERATOR SCOPE PATTERN, CHECK
MECHANICAL TACOMETER, C & D WHERE REQ.
0______________________________________________________________________________________________________
0 15 5030 +INCLUDES:
5070 BATTERY GROUND CABLE, D & C AT BATTERY
RUN ENGINE, CHECK GENERATOR FUNCTION
GENERATOR, R & R <(IN OPER. 5070)>
<OPER. NO. 5070 INCLUDES ADDITIONALLY: >
GENERATOR PULLEY, TRANSFER
<129 MODEL INCLUDES ADDITIONALLY: >
COOLING FAN SHROUD, R & R
COOLING FAN, R & R <(ENG. 119)>
COOLANT PUMP PULLEY, R & R <(119 ENG.)>
<140 MODEL INCLUDES ADDITIONALLY: >
COOLING FAN & SHROUD, R & R <(119 ENG.)>
TRANSM. OIL COOLER LINE, D & C AT OIL COOLER<(119/120 ENG.)>
FRONT TORSION BAR, D & C AT CHASSIS <(120 ENG.)>
15-X012
+ 15-XXX
-
<201 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER, R & R <(190E 2.3-16V)>
ELECTRICAL LINES FROM TERMINAL BLOCK, D & C <(190E 2.3-16V)>
VENTILATION COVER, TRANSFER <(OPER. 5070)>
VENTILATION COVER SHIELD, R & R <(190E 2.3-16V)>
+DOES NOT INCLUDE:
FAN/POLY-V BELT, REPL.
0______________________________________________________________________________________________________
0 15 5035 +INCLUDES:
+AFTER INSPECTION:
POLY-V BELT (SINGLE BELT DRIVE), REPL.
0______________________________________________________________________________________________________
15-X013
+ 15-XXX
-
15 5075 +INCLUDES:
GENERATOR, R & R
GENERATOR PULLEY, TRANSFER
VENTILATION COVER, TRANSFER (WHERE APPLICABLE)>
+AFTER INSPECTION:
POLY V-BELT (SINGLE BELT DRIVE), REPL.
0______________________________________________________________________________________________________
0 15 5760 +INCLUDES:
BATTERY GROUND CABLE, D & C AT BATTERY
GENERATOR REAR COVER, R & R WHERE REQ.
RUN ENGINE, CHECK GENERATOR FUNCTION
<116/117 ENGINES INCLUDE ADDITIONALLY: >
GENERATOR, LOOSEN / REINSTALL
<201 MODEL INCLUDES ADDITIONALLY: ) >
ELECTRICAL WIRING AT TERMINAL BLOCK, D & C <(190E 2.3-16V)>
VENTILATION COVER, R & R WHERE INSTALLED
0______________________________________________________________________________________________________
15-X014
+ 15-XXX
-
15 5780 +INCLUDES:
<201 MODEL: >
VENTILATION COVER, R & R WHERE APPLICABLE
VENTILATION COVER SHIELD, R & R <(190E 2.3-16V)>
0______________________________________________________________________________________________________
0 15 6052 +INCLUDES:
BATTERY GROUND CABLE, D & C AT BATTERY
ELECTRICAL WIRING AT GENERATOR/TERMINAL BLOCK, D & C
START ENGINE, CHECK GENERATOR FUNCTION
<201 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER, R & R <(102 ENG.)>
VENTILATION COVER, R & R WHERE APPLICABLE
VENTILATION COVER SHIELD, R & R <(190E 2.3-16V)>
0______________________________________________________________________________________________________
15-X015
+ 15-XXX
-
15 6700 +INCLUDES:
<102 ENGINE: >
COOLING FAN/PULLEY, R & R
POLY BELT, D & C
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R
GENERATOR, R & R
RUN ENGINE, CHECK REPAIR RELATED FUNCTIONS
<103 ENGINE: >
COOLING FAN AND SHROUD, R & R
POLY BELT, D & C
COOLING FAN PULLEY, R & R
CRANKSHAFT PULLEY & VIBRATION DAMPER, R & R
GENERATOR, D & C WITH WIRING CONNECTED
RUN ENGINE, CHECK REPAIR RELATED FUNCTIONS
0______________________________________________________________________________________________________
0 15 6702 +INCLUDES:
COOLING FAN PULLEY, R & R
CRANKSHAFT PULLEY/VIBRATION DAMPER, R & R
0______________________________________________________________________________________________________
15-X016
+ 15-XXX
-
15 7020 +INCLUDES:
STARTER MOTOR, INSPECT FOR TIGHT INSTALLATION
ELECTRIC WIRING AT STARTER, CHECK FOR TIGHT CONNECTION
VOLTAGE SUPPLY TO ENGAUGE STARTER, TEST
STARTER CURRENT DRAW DURING CRANKING, TEST
STARTER MOTOR, CHECK FOR ABNORMAL NOISE DURING CRANKING
0______________________________________________________________________________________________________
0 15 7100 +INCLUDES:
7170 BATTERY GROUND CABLE, D & C AT BATTERY
ELECTRIC WIRING ON STARTER, D & C
STARTER MOUNTING SUPPORT BRACKET(S), R & R WHERE APPLICABLE
STARTER HEAT SHIELDS, R & R WHERE REQ.
RING GEAR ON FLYWHEEL/DRIVEN PLATE, INSPECT
FUNCTIONAL TEST AFTER REPAIR
<107 MODEL INCLUDES ADDITIONALLY: >
ENGINE SHOCK ABSORBER, REMOVE AS NEC. / REINSTALL
<124/126 MODELS INCLUDE ADDITIONALLY: >
AIR CLEANER, R & R <(103 ENG.)>
<201 MODEL INCLUDES ADDITIONALLY: >
AIR CLEANER, R & R
STARTER CABLE AND TERMINAL BLOCK, EXPOSE
CABLE BRACKET ON OIL FILTER HOUSING, R & R
15-X017
+ 15-XXX
-
SHIFT RODS, D & C
FRESH AIR INTAKE COWL, R & R <(190E 2.3 (41))>
W/WASHER RESERVOIR, R & R <(TURBO DIESEL)>
DRAG LINK, D & C AT GEAR BOX <(190E 2.3/2.3-16V)>
COOLING FAN SHROUD, R & R <(190E 2.3-16V)>
FRAME CROSSMEMBER, R & R <(190E 2.6)>
EXHAUST SYSTEM HANGERS, D & C AT REAR <(190E 2.6)>
LEFT ENGINE MOUNT, LOOSEN / REINSTALL <(190E 2.3-16V)>
INTAKE MANIFOLD SUPPORT, LOOSEN / REINSTALL <(190E 2.3-16V)>
<202 MODEL INCLUDES ADDITIONALLY; >
EXHAUST SYSTEM, D & C AT REAR HANGERS <(C280 M104)>
TRANSM. REAR SUPPORT MEMBER, LOOSEN / REINSTALL <C280 M104)>
+AFTER INSPECTION: ALL MODELS
RUBBER BOOT AT CABLE END, REPL.
0______________________________________________________________________________________________________
0 15 7175 +INCLUDES:
ELECTRIC WIRING ON STARTER, D & C
+AFTER INSPECTION:
RUBBER BOOT AT CABLE END, REPL.
0______________________________________________________________________________________________________
15-X018
+ 15-XXX
-
15 7780 +INCLUDES:
BATTERY GROUND CABLE, D & C AT BATTERY
AIR CLEANER, R & R WHERE REQ.
0______________________________________________________________________________________________________