---

00 Maintenance Jobs - 1994 through 1997

• Introduction
• 0053 - Inspecting components, lines and hoses
• 0090 - Suspension and body structure inspection
• 0101 - Engine oil and filter change
• 0760 - Checking injection timing
• 0761 - Adjusting injection timing
• 0780.1 - Replacing fuel filter (Diesel engines)
• 0780.4 - Replacing fuel filter (M104, M119, M119 with LH-SFI)
• 0780.5 - Replacing fuel filter (M104, M119 with HFM-SFI)
• 0781 - Replacing fuel prefilter
• 0932 - Cleaning metal-reinforced air filter element
• 0980 - Replacing air filter element
• 1351 - Inspecting poly-V-belt
• 1550 - Check spark plugs, replace if necessary
• 1580 - Replacing spark plugs
• 2010 - Checking coolant level/antifreeze protection
• 2080 - Replacing coolant
• 2702 - Automatic transmission fluid and filter change
• 3022 - Inspecting, lubricating throttle linkage
• 3211 - Level control, ADS, ASD fluid level
• 3353 - Checking front axle ball joints
• 3355 - Checking ball joints using special tool
• 3501 - Rear axle oil change
• 4050 - Inspecting/rotating wheels
• 4051 - Inspecting tires
• 4060 - Correcting tire pressure
• 4070 - Tightening wheel bolts
• 4152 - Inspecting drive shaft flexible coupling
• 4210 - Checking brake fluid level
• 4251 - Checking brake pad/disk thickness
• 4256 - Inspecting parking brake cable
• 4261 - Adjusting parking brake
• 4280 - Replacing brake fluid
• 4290 - Brake test, parking brake check
• 4611 - Checking power steering fluid level
• 4650 - Checking steering play
• 4671 - Retightening steering bolts
• 4971 - Retightening exhaust system connections
• 5410 - Checking and correcting battery fluid level
• 5451 - Checking warning and indicator lamps
• 6190 - Removing and installing engine compartment lower panel
• 7710 - Hydraulic top, checking and correcting fluid level
• 7730 - Sun roof, clean and grease rails
• 7750 - Soft top, checking locking tabs
• 8210 - Checking, correcting windshield washer fluid level
• 8230 - Cleaning cassette deck tone head
• 8231 - Cleaning antenna mast
• 8251 - Headlamp and exterior lamp inspection
• 8252 - Windshield and headlamp wiper/washer inspection
• 8280 - Replacing windshield wiper blade
• 8312 - Checking, correcting A/C refrigerant charge
• 8381 - Replacing dust filter for heating/ventilation
• 8382 - Replacing active charcoal filter
• 8383 - Replacing recirculating air filter
• 8384 - Replacing activated charcoal prefilter
• 8821 - Lubricating hood
• 9150 - Inspecting safety belts for damage
• 9151 - Backrest lock - check operation
• 9490 - Removing and installing lower noise encapsulation panels
• 9850 - Checking body for paint damage
• AP83_00-8381 - Replacing dust filter for heater/ventilation